HOW TO MAKE GOUACHE PAINT
Many years ago I learned how to make my own gouache paint, since all the commercial brands I could find at that time were in small tubes that I used up rather quickly. Raw pigment was also more difficult to find back then. Here’s a sample batch I made of some burnt umber gouache.
The mixture below will make about 1 ounce of gouache paint.
Optional: 1-2 drops preservative: Oil of clove, Thymol, or even unscented Lysol will work. Not required, but will help prolong the life of the mixture.
Place pigment on a large glass or plexiglass pane. I usually dump out about 1 teaspoon of pigment at a time.
Make an indentation in the pigment pile. Add a small amount of binder solution and mix together thoroughly. A good target is half as much binder as pigment (1:2) but some pigments require less. Keep adding just enough binder to make a smooth paint to your liking. If it gets too wet, add more pigment. Any pigment that is difficult to get wet can be helped along with a teaspoon of grain alcohol.
Keep scraping the paint back into a pile to keep it all wet so it won't dry on you. Mist with water if necessary. 20 to 30 minutes is the most mixing time you should need, often less.
Using the palette knife, lay down a small swatch of fresh paint on a clean spot of the mixing plate in a layer that has thick and thin spots. Let that air dry for several minutes COMPLETELY (this may take longer than you think – give it 20-30 minutes or so.) Rub the dried paint with a cloth. If it feels gritty, you need to do more mixing. If paint lifts off completely then there’s not enough binder. If it just slightly stains the cloth that should be fine. If the dried paint has cracks then there’s too much binder. Those can be hairline cracks, so I like to make a high-res computer scan of the dried paint to be certain.It's useful to do the same test with a high quality commercial paint to make an accurate comparison.
Please remember that pigments have certain health hazards and require careful handling in powder form. Don't be messy and wash everything thoroughly. A respirator and laytex gloves can be used as an extra precaution.
Dry pigments clump together and need to be broken down and coated with binder to make a proper paint. That is usually referred to as "grinding," but I believe mulling is a better term - it's more like rubbing. You can't over do it, but you can under do it.
Some pigments can be grittier than others, which will take longer to mix. Usually a flat metal palette knife or spatula is all I need. If the pigment is very gritty, I'll move up to a mortar and pestle. I have a glass muller but find it's rarely necessary unless I'm making large amounts of paint or want it extra smooth for thin washes. A rough frosted glass pane is best as a work surface.
There are pigments on the market sold as water dispersions. These are pigments mixed with water and small amounts of other things to keep them wet. The benefit of these is that the liquid keeps the pigments from clumping together so no grinding is necessary. You need to account for that water in your mixture, however, so that the paint isn't too thin. They're often more expensive than dry powders also.
Supplies can be found at various stores that cater to pigment supplies, including grinding slabs, mortars, mullers, etc. Oxgall is often found in the watercolor section of art stores. Glycerin is used in candlemaking, gum arabic in cake decoration. Dextrin is used in brewing beer, or making fireworks. You can make yellow dextrin by roasting corn starch for 10 minutes in a 400° oven. Shop around, but make sure you buy pure ingredients.
Some Pigment Suppliers:
Kama Pigments, Sinopia, Guerra, Natural Pigments, Zecchi
If you find yourself using up those tiny tubes of paint, making your own can be much more economical, especially for expensive or hard to find colors. You also have more control over paint quality.
Gouache is one of the simplest paints you can make, short of egg tempera. The only issue is finding all the ingredients, but it's all available online. This pre-mixed binder can keep for several years, as will the paint. If it dries out, it re-wets easily.